$39 Floor Furnace Service Call

There are 3 main manufacturers for floor furnaces. Cozy floor furnaces, Williams floor furnaces and Empire floor furnaces. We are not affiliated with Empire floor furnaces. Every one of the manufacturers requires a yearly inspection of your floor furnace for safety.

What is a Floor Furnace Safety Check Up?

We check for gas leaks, pilot burner problems, venting problems, thermostat problems and cracks in the heat exchanger or firebox. We will clean out the furnace and venting and get your floor furnace in tip top shape for another heating season.

We Repair All Existing Floor Furnace Brands

It doesn’t matter how old your floor furnace is. It doesn’t matter that the controls for your floor furnace are no longer made. There is a replacement or substitution part on the market that will work. The only part of your older floor furnace that cannot be repaired is the firebox or heat exchanger should it be ruptured.

We Install New Floor Furnaces

We install 25,000 btu floor furnaces, 35,000 btu floor furnaces and 50,000 btu floor furnaces. We normally install the Cozy Brand, but we can get any brand that you wish.

We Install New Floor Furnaces in Bedrooms

Yes, it is code approved to install a normal floor furnace in a bedroom if the room is large enough. If the room is not large enough we can install a direct vent floor furnace that uses outside combustion air.

Typical Floor Furnace Problems We Can Solve For You

  • Banging Noises
  • Pilot Outage Problems
  • Water Intrusion
  • Short Cycling (On-off not reaching temperature)
  • Gas Leaks
  • Thermostat Problems
  • Limit Switch Problems (Tripping)
  • Conversions to a Wall Thermostat
  • Conversions to a Wall Heater
  • Conversions to Forced Air Heating

Can I Replace My Dual Wall Floor Furnace?

This is a floor furnace than spans a wall typically from the living room to a hallway. No, this floor furnace cannot be replaced as it is no longer manufacturered. The problem with these floor furnaces is that they allow the interior of the wall above them to become too hot. There have been a great many fires related to this furnace and we have removed many of them to find the entire interior of the wall burned from heat.

They can still be fixed, but once the heat exchanger of this floor furnace (firebox) is ruptured, it must be converted to another type of heating unit. Floor furnaces are still manufactured, but they are the style that only serves a single room. Most people opt for either a dual wall furnace or forced air heating.

What Happened To The Built In Valve With a Simple ON-Off Control?

  • The floor furnace that used to sold that had a simple on-off control is no longer code
    approved and is no longer manufactured. It simply didn’t have a minimum level of safety such as turning off when the home achieved the desired temperature.
    We can still fix those units as the valves are still manufactured and there are several valves on the market that can replace the orginal without any problems.